MASTER CORPORATION -- MASTER STEERING FLUID PSF-32  -- 9150-00F045737
<pre>=====================  Product Identification  =====================

Product ID:MASTER STEERING FLUID PSF-32
MSDS Date:02/10/1995
FSC:9150
NIIN:00F045737
=== Responsible Party ===
Company Name:MASTER CORPORATION
Address:1900 EXETER ROAD
Box:381900
City:GERMANTOWN
State:TN
ZIP:38138-1900
Country:US
Info Phone Num:901-755-5555
Emergency Phone Num:800-255-3924
CAGE:GO479
=== Contractor Identification ===
Company Name:MASTER CORPORATION
Address:1900 EXETER ROAD
Box:381900
City:GERMANTOWN
State:TN
ZIP:38183-1900
Country:US
Phone:901-755-5555
CAGE:GO479

=============  Composition/Information on Ingredients  =============

Ingred Name:HEPTANE		    *98-2*
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 67-77%
Other REC Limits:400 PPM
OSHA PEL:2000 MG/CUM
ACGIH TLV:1640 MG/CUM

Ingred Name:ETHYL ETHER, DIETHYL ETHER, ETHER, ANESTHETIC ETHER
CAS:60-29-7
RTECS #:KI5775000
Fraction by Wt: 10-20%
Other REC Limits:500 PPM STEL
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS

Ingred Name:CARBON DIOXIDE   *98-2*
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 4.8-15%
Other REC Limits:10000 PPM
OSHA PEL:5000 PPM
ACGIH TLV:9000 MG/CUM

Ingred Name:HEXANE, N-HEXANE	       *98-2*
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 2.7%
Other REC Limits:50 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:176 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: MILD
    IRRITATION & BURNS. INHALATION: IRRITATION TO THE NOSE, THROAT &
    RESPIRATORY TRACT. CNS DEPRESSION & DEATH. INGESTION: LOW TOXICITY,
    LARGE AMOUNTS MAY BE HARMFUL. GI IRRIT ATION. MATERIAL CAN ENTER
    THE LUNGS & CAUSE LUNG INFLAMMATION/DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, STINGING, TEARING, REDNESS,
    SWELLING, BLURRED VISION, DRYNESS, BURNING, CRACKING, NAUSEA,
    VOMITING, DIARRHEA, DIZZINESS, DROWSINESS, WEAKNESS, FATIGUE,
    HEADACHE, UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS, LUNG
    DISORDERS & ASTHMA LIKE CONDITIONS.

=======================  First Aid Measures  =======================

First Aid:EYES: REMOVE TO FRESH AIR. FLUSH GENTLY W/WATER FOR 15 MINS.
    SKIN: WASH W/SOAP & WATER. INGESTION: DON'T INDUCE VOMITING.
    ASPIRATION HAZARD. IF DROWSY/UNCONSCIOUS, PLACE ON LEFT SIDE W/HEAD
    DOWN. INHA LATION: REMOVE TO FRESH AIR. KEEP WARM & QUIET. GIVE
    CPR/OXYGEN IF NEEDED. OBTAIN MEDICAL ATTENTION IN ALL CASES.

=====================  Fire Fighting Measures  =====================

Lower Limits:1
Extinguishing Media:REGULAR FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SCBA W/A FULL FACEPIECE W/POSITIVE
    PRESSURE DEMAND MODE, APPROPRIATE TURN-OUT GEAR & CHEMICAL
    RESISTANT PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
    DRUM(EVEN EMPTY)PRODUCT(EVEN JUST RESIDUE)CAN IGNITE EXPLOSIVELY.

==================  Accidental Release Measures  ==================

Spill Release Procedures:SMALL: ALLOW TO EVAPORATE. ELIMINATE SOURCES
    OF IGNITION SUCH AS FLARES, FLAMES, PILOT LIGHTS & ELECTRICAL
    SPARKS. VENTILATE AREA. LARGE: EXCLUDE PERSONS NOT WEARING
    PROTECTIVE EQUIPMENT UNTIL LEAK HA S BEEN REPAIRED. ELIMINATE
    IGNITION SOURCES.

======================	Handling and Storage  ======================

Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED. SINCE
    EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES, ALL HAZARD PRECAUTIONS
    MUST BE OBSERVED.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF EXPOSURE LIMIT IS EXCEEDED, A NIOSH/MSHA
    APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED. OSHA ALSO PERMITS
    OTHER NIOSH/MSHA RESPIRATORS (NEGATIVE PRESSURE TYPE) UNDER
    SPECIFIED CONDITIONS.
Ventilation:SUFFICIENT MECHANICAL (GENERAL)/LOCAL EXHAUST TO MAINTAIN
    EXPOSURE BELOW TLVS.
Protective Gloves:NOT REQUIRED
Eye Protection:NOT REQUIRED
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
    REUSE.
Supplemental Safety and Health

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:94F
Vapor Pres:439
Vapor Density:>1
Spec Gravity:0.773
Evaporation Rate &amp; Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:CLEAR LIQUID HOMOGENEOUS SOLUTION
Percent Volatiles by Volume:100%

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CO2 & CO, VARIOUS HYDROCARBONS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
    REGULATIONS. UN 1960.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.